Symptom
|
Suspect Area
|
Remedy
|
Water leaks from
sunroof
|
Dirt accumulated in drain tube
|
Clear dirt inside of drain
|
Clogged drain tube
|
Blow air into drain to remove dirt
|
Broken or dislocated drain tube, defective or cracked
clip
|
Check tube installation and flange
contact
|
Deteriorated roof lid weatherstrip
|
Replace
|
Excessive roof lid-to-body clearance and improperly
fitted weatherstrip
|
Adjust
|
Wind noise around sunroof
|
Loosen or deformed deflector, gaps in body
work
|
Retighten adjust or replace
|
Sunroof lid makes a noise when
move
|
Foreign particles lodged in guide rail
|
Check drive cable and guide rails for foreign
particles
|
Loosen guide rails and lid
|
Retighten
|
Motor runs but sunroof does not move
or moves only partially
|
Foreign particles lodged in guide rail
|
Check drive cable and guide rails for foreign
particles
|
Incorrect engagement of motor pinion with drive
cable
|
Check for loosen motor installation and damaged
pinion
|
Decrease in motor`s clutch slipping force
|
Adjust
|
Increased sunroof sliding resistance or interference of
sunroof with drive cables, weatherstrip, etc. due to mal adjustment
of sunroof
|
Adjust or replace
|
Noise in motor (clutch slipping noise
from motor when sunroof is fully opened or closed is not an unusual
noise
|
Incorrect engagement of motor pinion With drive
cable
|
Check pinion installation and Retighten
motor
|
Worn out or damaged motor pinion bearing
|
Replace motor assembly
|
Worn out or deformed drive cable
|
Replace
|
Door glass fails to operate up or
down
|
Incorrect window glass installation
|
Adjust position
|
Damaged or faulty regulator arm or
regulator
|
Correct or replace
|
Door does not open or close
completely
|
Incorrect door installation
|
Adjust position
|
Defective door check assembly
|
Correct or replace
|
Door hinge requires grease
|
Apply grease
|
Hood does not open or close
completely
|
Striker and latch not properly aligned
|
Adjust
|
Incorrectly installed hood
|
Adjust
|
Incorrect hood bumper height
|
Adjust
|
Water leak through windshield or rear
window
|
Defective seal
|
Fill with sealant
|
Defective flange
|
Correct
|
